Start Problem

[Chester]

Tried all sorts,can anyone help? Saxo1.5D Until recent it started 1st try now takes 3 or 4 goes and getting worse plus orange engine outline warning light coming up now. Changed glowplugs,removed and checked injectors,no luck still same........

[tiger1983]

Pre heat relay?

[Chester]

Thanks very much for pointer, do you know where relay is?

[tiger1983]

No idea to be honest, I've never worked on a diesel saxo

[oxass]

Have drained the water out of the fuel filter?
Also check for air in the fuel line there should be a clear hose from the pump check it for bubbles.
I think the glow plug relay is on slam panel passenger side.

[Chester]

Thanks tiger 1983. Also thanksoxass, have done service,oil change fuel filters,etc fault still there but car runs fine when started its just getting it to start,it turns over but takes 3 or 4 tries before you get anywhere. I`m not bad on mechanical side but not good on electrics still can't find preheat relay.

[oxass]

It is a black plastic box about 5" x 4" with a bracket on the top with one fastener securing it and several wires conected to the bottom.

[Chester]

Thanks oxass , will have a go at it again tomorrow, will let you know if I get it sorted,thanks again.